| Variant | Engine | Drivetrain | Transmission | City | Highway | Combined | EV Range | Est. Annual Fuel Cost |
| SS | 6.2L 8-Cyl | Rear-Wheel Drive | Manual 6-spd | 14 MPG | 22 MPG | 17 MPG | — | $3,600 / yr |
| SS | 6.2L 8-Cyl | Rear-Wheel Drive | Automatic (S6) | 14 MPG | 20 MPG | 16 MPG | — | $4,750 / yr |
Data Boundary Note: EPA specifications are shown by certified vehicle configuration. NHTSA complaints and recall totals are recorded at the model-year level across all configurations.
| Tested Drivetrain / Cab Variant | Overall Rating | Frontal Crash | Side Crash | Rollover Rating | Rollover Risk |
| 4 DR RWD | Not Rated | Not Rated | Not Rated | Not Rated | — |
Active Driver Assistance Systems (NHTSA Recorded): Forward Collision Warning (FCW) is documented as Standard and Lane Departure Warning (LDW) is documented as Standard in official NHTSA records for tested 2016 Chevrolet SS models.
View complete 2016 Chevrolet SS crash test & safety breakdown →
Top Reported Problem Categories
Ranked by total consumer complaint submissions recorded by NHTSA
Data Attribution & Context: Complaints are self-reported by vehicle owners to NHTSA and represent unverified consumer submissions. Complaint volume does not equal a statistically controlled failure rate and is not adjusted for total vehicles sold or cumulative mileage driven.
View all 2016 Chevrolet SS problems & component breakdown (9 categories) →
Affected Component: SEAT BELTS:FRONT
Defect Summary: General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV) that were previously repaired under NHTSA recall number 16V-518. The repair may not have been performed properly. The driver's seat belt tensioner cable may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Free Manufacturer Remedy: GM will notify owners, and dealers will inspect the vehicles to determine whether the new seat trim was installed and replace the trim as necessary. Dealers will also inspect and replace the pretensioner cable assembly, as necessary. Repairs will be performed free of charge. The recall began November 17, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202312100
Affected Component: STEERING
Defect Summary: General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Caprice Police Pursuit vehicles (PPV) and SS vehicles. Corrosion of the connector between the electric power steering module and the torque sensor connector may cause a loss of electric power steering assist.
Free Manufacturer Remedy: GM will notify owners, and dealers will replace the steering gear assembly, free of charge. The recall began May 26, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N192285350.
Affected Component: STEERING:ELECTRIC POWER ASSIST SYSTEM
Defect Summary: General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS vehicles that previously received an inspect-only remedy under recall 17V-382. Corrosion of the connector between the electric power steering module and the torque sensor connector may cause a loss of electric power steering assist.
Free Manufacturer Remedy: GM will notify owners, and dealers will replace the steering gear assembly, free of charge. The recall began December 27, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GM customer service at 1-586-596-1733. GM's number for this recall is N192265980.
View all 2016 Chevrolet SS recalls & campaign history (7 campaigns) →
